Coal Fired Boiler For Sale High Efficiency Fast Delivery

What Is Your Coal Fired Boiler For Sale Advantage?

1. Our coal fired boiler for sale is divided into two parts, one part includes the boiler body and the steel frame upper furnace wall, and the other part includes the coal hopper, the chain grate, the base steel frame and the lower furnace wall. Except for the middle partition wall construction, the other components are assembled and shipped. The tail cast iron economizer and the air duct of the boiler are shipped with the furnace.

2. Yongxing coal fired boiler for sale burning part adopts light chain grate, and the air enters on both sides. There are six independent air chambers under the grate. There are air conditioning mechanisms on both sides of the air chamber. The air is blown into the lower part of the base by the blower. The wind machine enters the independent wind room.

3. Yongxing Boiler shaft is made of refractory concrete. The rear arch is low and long, so the combustion effect is good. The two-wing flue and the sidewall brick are made of refractory sintered brick. General refractory bricks are used for the front and rear walls of the boiler.

4. our coal fired boiler for sale chain grate has a reasonable air distribution, the combustion chamber is large, and the coal type has strong applicability. Adapt to all types of bituminous or anthracite, mixed coal. The fuel is fully burned. Since the high-temperature flue gas will enter the settling chamber and then enter the flue from both sides, the exhaust and dust removal effect of the equipment is very good.

5. The water circulation is simple, the structure of the pressure-bearing parts is reasonable, and it can be safely operated under the condition of ensuring water quality. At the same time, high-standard, high-quality auxiliary machines, accessories and automatic control equipment are used to ensure safe and stable operation of the boiler.

6. Avoid drum bag defects:

The riser pipes of the two sides of the header are pulled toward the furnace, and the bottom of the drum is introduced below the bottom of the drum and the bottom of the drum is covered with thermal insulation material constitutes the heating surface of the top of the furnace.

The bottom of the drum is successfully solved with a novel furnace structure. Subject to high temperature flame radiation problems, to avoid "bulk bag" defects.

7. Our boiler shell adopts an elliptical head and the grate adopts a cast iron circular grate, which has the characteristics of high reliability and long service life.

What Is Your Design Of Coal Fired Boiler For Sale?

1. Before starting the boiler, check the power supply, voltage, water source, fuel abnormality, close the drain valve, open the water supply valve, and check whether the flue is unobstructed. In addition, check the pressure of the furnace body and the operation of the make-up pump to confirm whether the motor can work normally. Check the working status of the pump. After all the above devices have been confirmed, they can be turned on.

2. This product belongs to Biomass Steam Boiler. Please be sure to install water softener when using this equipment according to the boiler water quality requirements. Because the hard water quality will cause boiler fouling, it will cause tube explosion when it is serious. Shorten the life of the boiler. Failure to use the water treatment equipment as required to cause damage to the boiler is not covered by the warranty.

3. Please pay attention to the timed sewage when using the steam boiler. Discharge at least once a day and discharge at a pressure of 0.15 MPa to 0.25 MPa. This can effectively prevent pipe blockage. In addition, the sewage pipe should be connected according to the regulations, beware of the operator's burns.

What Is Your Coal Fired Boiler For Sale Technical Data?